IBC Code emergency escape sets
What is being checked
The inspector is checking whether the complete arrangement for IBC Code emergency escape respiratory protection meets the cargo-code requirement, remains immediately usable and is understood by the personnel assigned to use it.
Ready onboard
0/6 completePractice questions
Answer aloud, then open the preparation point.
1Why is this scale of IBC Code emergency escape respiratory protection required?
Relate escape sets for each person and additional sets at specified locations to the cargo code, Certificate of Fitness, muster duties and vessel arrangement.
2How do you check it before use?
Check completeness, suitability, service status and the defects most likely to prevent protection: expired units, low pressure, damaged hoods, broken seals, inaccessible stowage or wrong locations.
3How is it used safely?
Demonstrate or explain rapid donning, activation, route selection and escape while recognising that the set is not for firefighting or tank entry, including withdrawal and decontamination limits.
4What if an item is defective or missing?
Replace it with an equivalent approved item, control affected cargo work and record the defect and restoration.
5How do you confirm compatibility with today's cargo?
Use the Certificate of Fitness, cargo SDS and maker limitations rather than relying on colour or general familiarity.
Where an observation may arise
The inventory did not provide the required arrangement for escape sets for each person and additional sets at specified locations.
Inspection identified expired units, low pressure, damaged hoods, broken seals, inaccessible stowage or wrong locations.
The equipment material, cartridge, cylinder or clothing was unsuitable for the cargo hazard.
Testing, service, calibration or replacement was overdue or not traceable.
Required equipment was obstructed, unmarked or stored where contamination could prevent access.
Assigned personnel could not explain rapid donning, activation, route selection and escape while recognising that the set is not for firefighting or tank entry.
Master's practical note
Select equipment from the station closest to the cargo risk, not only the best-maintained locker. The weakest required set determines actual readiness.
Equipment boundary and references
Equipment boundary: Use training or demonstration equipment where available. Do not consume filters, break seals or impair emergency equipment solely for inspection.
References
- OCIMF SIRE 2.0 Question Library Part 2, Version 1.0, Question 8.2.6
- IMO IBC Code Chapter 14
- IMO FSS Code Chapter 3
Last reviewed: 2026-09-14